Ford Kuga

 Service Manual

Supplemental Restraint System
Restraints Control Module (RCM)

General Equipment

Ford approved diagnostic tool

Removal

WARNINGS:

• The supplemental restraint system (SRS) is active for a certain length of time after the power supply has been disconnected.

  Wait for a minimum of 3 minutes before disconnecting or removing any SRS components.

• Make sure that the vehicle electrical system is fully depowered and no other power source is connected.
• Wear safety goggles.
• Refer to: Supplemental Restraint System (SRS) Health and Safety Precautions (100-00 General Information, Description and Operation).

NOTE: Removal steps in this procedure may contain installation details.

1. Refer to: Battery Disconnect and Connect (414-01 Battery, Mounting and Cables, General Procedures).

2. Refer to: Floor Console (501-12 Instrument Panel and Console, Removal and Installation).

3. Torque: 8 Nm

Installation

1. To install, reverse the removal procedure.

2. When a new RCM is installed, configure the RCM using the diagnostic tool.

General Equipment: Ford approved diagnostic tool

Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS) (Overview)

Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS) (System Operation and Component Description)

Air Bag and Safety Belt Pretensioner Supplemental Restraint System (SRS) - Vehicles Built From: 06/2004

Clockspring Adjustment

Deployed Air Bag Disposal

Scrapped Vehicle Air Bag and Safety Belt Pretensioner Disposal - In-Vehicle Disposal

Unserviceable Air Bag Disposal

Front Impact Severity Sensor

Crash Sensor

Driver Air Bag Module

Passenger Air Bag Module

Restraints Control Module (RCM)

Side Air Bag Module

Side Air Curtain Module

Clockspring