Ford Kuga

 Service Manual

Climate Control
Heater Core - RHD(34 364 0)

General Equipment

Air Body Saw

Hose Clamp(s)

Removal

NOTE: Removal steps in this procedure may contain installation details.

1. Refer to: Brake System Health and Safety Precautions (100-00 General Information, Description and Operation).

2. Refer to: Engine Cooling System Health and Safety Precautions (100-00 General Information, Description and Operation).

3. Extract brake fluid from the brake fluid reservoir until the level reaches the MIN mark.

4. Refer to: Cowl Panel Grille (501-02 Front End Body Panels, Removal and Installation).

6. CAUTION: Make sure that all openings are sealed.

General Equipment: Hose Clamp(s)

7.   CAUTION: Make sure that all openings are sealed

8. Refer to: Floor Console (501-12 Instrument Panel and Console, Removal and Installation).

9. Torque: 9 Nm

11. Torque: 28 Nm

12Torque: 28 Nm

13LTorque: 25 Nm

4. Refer to: Climate Control Assembly - Vehicles With: Manual Temperature Control (412-01 Climate Control, Removal and Installation). Refer to: Climate Control Assembly - Vehicles With: Automatic Temperature Control (412-01 Climate Control, Removal and Installation).

15 1. Torque: 10 Nm

2.  Torque: 25 Nm

17. 1. If equipped.

19.  WARNING: Be prepared to collect escaping fluid.

General Equipment: Air Body Saw

Installation

2. To install, reverse the removal procedure.

3. Check the coolant level.

Refer to: Cooling System Draining and Vacuum Filling (303-03 Engine Cooling, General Procedures).

Condenser

Clutch and Clutch Field Coil

Pollen Filter - RHD

Blower Motor - RHD(34 374 0)

Blower Motor Resistor - Vehicles With: Manual Temperature Control, RHD(34 382 0)

Blower Motor Resistor - Vehicles With: Dual Automatic Temperature Control(34 382 0)

Heater Core and Evaporator Core Housing

Heater Core - RHD(34 364 0)

Suction Accumulator

Suction Accumulator to Air Conditioning (A/C) Compressor Line

Suction Accumulator to Air Conditioning (A/C) Compressor Line - 2.5L Duratec (147kW/200PS) - VI5

Low-Pressure Cutoff Switch

High-Pressure Cutoff Switch

Evaporator

Evaporator Outlet Line

Evaporator Core Orifice

Condenser to Evaporator Line

Climate Control Assembly - Vehicles With: Manual Temperature Control(34 300 0)

Climate Control Assembly - Vehicles With: Automatic Temperature Control(34 300 0)

Footwell Air Discharge Temperature Sensor(34 485 4)

Center Register Air Discharge Temperature Sensor

In-Vehicle Temperature Sensor

Footwell Vent/Duct Blend Door Actuator - RHD(34 591 0)

Air Inlet Blend Door Actuator(34 606 0)

Driver Side Temperature Blend Door Actuator(34 608 0)

Passenger Side Temperature Blend Door Actuator(34 608 0)

Defrost Vent/Register Blend Door Actuator - RHD(34 591 0)